All our servicing is carried out by factory trained technicians, once we have carried out initial checks you will be contacted and given guidance and advice as to the costs involved.  
These are pictures of vehicles being serviced in our workshops, annual service check list is as follows
SERVICING SCHEDULE CARD
(Not 589 engines)
Owner: Date: Mileage:
5000m or 10,000 mile Reg No: Chassis No:
5K 10K Description of Task Comment X
X X Drain engine sump & refill - replace filter    
X X Check drive belts - report on condition - adjust    
X X Check ignition timing (Non EFI)    
X X Clean engine & compartment    
X   Inspect & reset spark plug electrode gap    
  X Replace spark plugs    
X X Check all fuel lines for damage & leakage    
X X Check/Adjust idle speed (EFI)    
X X Check operation of throttle potentiometer using Unitester (EFI)    
X X Check & adjust engine mixture settings if nec.    
  X Strip & clean carbs - adjust float levels (carb cars)    
X X Reset vacumn & mixture settings (carb Cars)    
  X Renew fuel filter (All)    
  X Renew air filter elements    
X X Inspect & report on exhaust condition - check fixings    
X X Check coolant level & antifreeze content    
X X Check & report on condition of hoses & system    
X X Check operation of cooling fans    
  X Check & report on condition of viscous coupling    
X   Check & top-up gearbox oil level (Auto & Manual)    
  X Drain & refill gearbox oil (Auto & Manual) see recommdations.    
X X Check condition & security of engine & gearbox mounts    
  X Check function & synchro of kickdown linkages    
X X Lubricate all linkages    
X X Check location - lubricate prop shaft universal joints    
X X Check adjustment & function of clutch hydraulic system    
X   Check hypoid unit oil level    
  X Change hypoid oil - add additive (AML pt. No. 8175)    
  X Check security & advise on condition of hypoid mounts    
X X Check security of drive shafts & lubricate all joints    
X X Check hydraulic fluid level (Power Steering)    
X X Check rack & column mounts & UJ's for security & wear    
  X Lubricate nipple sparingly    
X X Check/adjust steering track settings    
X X Check & advise on condition of track road ends    
X X Check & advise on condition of all gaiters & mountings    
X X Check security of all mounting points    
X X Check & advise on condition of all rubbers & mountings    
X   Check & adjust front hub bearings    
  X Strip out & replace front hub grease-Advise condition of bearings    

 

5K 10K Description of Task Comment X
X X Lubricate king pins - check & advise on any wear    
X X Visually inspect all shock absorbers for leakage & wear    
X X Check condition & security of all suspension mounts & linkages    
X X Check & top-up brake hydraulic fluid    
  X Drain & replace brake fluid @ 20,000 mile intervals only    
X X Inspect all hydraulic lines - report all defects    
X X Adjust & lubricate handbrake mechanism    
X X Remove, inspect, replace (if Nec) footbrake pads (deglaze discs)    
  X Advise on condition of handbrake pads    
X X Check security of all brake discs * mountin gs    
X X Check all tyre pressures & wear    
X X Check balance of all road wheels    
X X Check & torque all wheel nuts    
X X Check condition & charge of battery    
X X Clean & check security of all terminals. Apply petr. Jelly    
X X Check & advise on correct function & cycling of A/C    
X X Check security of all wiring harnesses & components    
X X Check operation of all electrical components for defects    
X X Check - replenish spare fuse provision    
  X Check & adjust headlamp beam settings    
X X Check, top up, adjust windscreen/headlamp washers    
X X Check condition & operation of windscreen wipers    
X X Check bodywork - bumpers for damage & security    
X X Check interior & boot for leaks, damage & report    
X X Lubricate all hinges & pivot points    
X X Check correct operation of all locks & catches    
X X Clean all drain tubes & holes as required    
X X Check correct operation of seat belts    
X X Check hydraulic fluid level in hood motor (Volante)    
X X Check correct operation of hood locks (Volante)    
X X Check consistency of fire extinguisher (if fitted)    
X X Lubricate all grease nipples & pivot points    
  X Touch in underseal as necessary    
RECOMMENDATIONS
Every 10,000 Miles Check & adjust engine timing chains - adjust valve timing & tappets  
(16,000Km) or 1 Year Carry out full air conditioning service - replace drier bottle  
  Check air conditioning compressor oil level  
  Carry out full automatic transmission service  
  Check & adjust steering geometry  
Every 20,000 Miles Check & report on fuel pump delivery  
(32,000Km) or 2 Years Drain, flush & re-antifreeze cooling system  
Every 30,000 Miles Strip out & overhaul king pins  
(48,000Km) or 3 Years Replace handbrake pads  
Every 40,000 Miles Strip out & replace rear hub grease. Advise on condition of bearings  
(64,000km) or 4 Years    
Every 50,000 Miles Replace front  & rear suspension rubbers  
(80,000Km) or 5 Years Replace front  & rear shock absorbers  
  Strip out & overhaul brake system. Replace all hydraulic seals  
  Replace brake vacumn valves  

 

We only use genuine AML parts

 
 Servicing is also about preventative maintenance as you can see the above was left a little to late (but all repairable).